CLEAN BURN CB-2800 Operator's Manual download pdf (Page 37)

Operator's Manual: Models CB-1500 & CB-2500 (230 V / 50 Hz)

4-3

Figure 4A - Typical CB-2500 Furnace Installation (CB-1500 is similar)

WITH TUBING BENDER

RADIAL BEND MADE

OF COPPER TUBING

BOTTOM TO CREATE SLUDGE TRAP

305 mm (12 IN.) OFF TANK

CHECK VALVE IS MINIMUM

INSIDE TANK:

CONTINUOUS PIECE

TO HOLD TUBING

INSTALL SLIP FITTING

IN PLACE

I88890−B

COMPRESSED AIR LINE

CLEAN BURN RECOMMENDS THAT

HORIZONTAL STACK NOT EXCEED 60% OF

VERTICAL STACK LENGTH

STACK SIZE:

STACK COMPONENTS AND

WARNING! FOLLOW LOCAL

MANUFACTURER’S

CODES AND STACK

SPECIFICATIONS TO ENSURE

SAFE CLEARANCES BETWEEN

COMBUSTIBLES

OR ROOF STRUCTURE WITHIN 3 m (10 FT) OF IT.

ROOF, AND AT LEAST 61 cm (2 FT) HIGHER THAN ANY RIDGE, PARAPET

ABOVE THE HIGHEST POINT AT WHICH IT COMES IN CONTACT WITH THE

NOTE: THE LAST STACK SECTION SHALL EXTEND AT LEAST 92 cm (3 FT)

SPACER. DO NOT CREATE FIRE HAZARDS!

WARNING! NEVER LOCATE A STACK JOINT INSIDE WALLS OR IN A JOIST

NOT PRIME AND/OR THE FLOW RATE FROM

VERTICAL SUCTION LIFT OR THE PUMP WILL

CAUTION: DO NOT EXCEED 183 cm (6 FT)

THE PUMP MAY DECREASE

GASOLINE FUMES IN YOUR SHOP. CHECK LOCAL CODES.

244 cm (8 FT) MIN. FROM FLOOR TO FURNACE IF THERE IS A POTENTIAL FOR

3 m (10 FT) MIN. VERTICAL STACK HEIGHT

3 m

(10 FT)

CONNECTOR BLOCK

BALL VALVE

MAXIMUM 183 cm (6 FT)

VENT

CAP

EMERGENCY

VENT VALVE

WARNING: When installing

your furnace, adhere to the

clearances from

combustible surfaces as

stated in Section 4,

These clearances also provide

adequate space for servicing.

Failure to maintain proper

clearences may result in fire,

explosion, personal injury or

death.

61 cm

(2 FT)

MIN. 20 cm (8 IN.)

16 mm (5/8") O.D.

FUNNEL WITH

BALL VALVE

Danfoss

Type BHO 64

Nr. 057H7036

ts 10s

220-240V 50-6 0Hz 3W

AIR OIL

1 2 ... 32 33 34 35 36 37 38 39 40 41 42 ... 121 122

Comments to this Manuals

No comments

CLEAN BURN CB-2800 Operator's Manual Page 37

Comments to this Manuals

Related products and manuals for Water heaters & boilers CLEAN BURN CB-2800